Smart-power-systems Liberator Series Bedienungsanleitung

THE LIBERATOR™ HYDRAULIC GENERATOR PLUS RESCUE TOOL PUMP SYSTEM OWNER’S MANUAL MODEL#: LI-15, LI-20, and LI-25

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 9 of 54 System Specifications MODEL OF GENERATOR LI-15 LI-20 LI-25 Generator Type Speed Fr

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 10 of 54 MODEL OF GENERATOR LI-15 LI-20 LI-25 Oil Cooler Dimensions (Core) 7.5”D x 18.

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 11 of 54 Pre-Installation Guide Pre-Installation Check List 1. Verify that the Power Take

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 12 of 54 The pumps supplied by Smart Power® Systems for Models LI-15, LI-20, and LI-25 ha

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 13 of 54 WARNING: Do not install hose ends until proper hose length has been determined. N

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 14 of 54 Bottom view of LI-15, LI-20, and LI-25 tray assemblies showing minimum clearance fo

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 15 of 54 Side view of LI-15, LI-20, and LI-25 tray assemblies showing tray dimensions and

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 16 of 54 WARNING: Do not mount the hydraulic pump or tray assembly in any location that is

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 17 of 54 Installation Guide For A.C. Modular Generator System (Reference XRT Manual for In

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 18 of 54 3. Mount the tray assembly as high as possible within the structure of the vehicl

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 1 of 54 Table of Contents Section Page Disclaimer ...

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 19 of 54 LI-15, LI-20, and LI-25 tray assemblies disassembled into base tray assembly (wit

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 20 of 54 .208CLEARANCE HOLEFOR #10 SCREW4 PL.2.0003.3753.3751.6881.688 Hole pattern for Comm

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 21 of 54 Hose connection locations for LI-15 tray assembly Figure 11A Hose connection lo

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 22 of 54 WARNING: ever operate the system with the pump case drain plugged. Damage to the

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 23 of 54 8. Connect the vehicle’s breaker panel to the generator output. The generator is

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 24 of 54 Do not perform any wiring installations or modifications while the system is operat

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 25 of 54 controller. The system controller will reset the option once the following two con

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 26 of 54 Enabling System Purge Option The purge option can also be set by performing the f

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 27 of 54 displays the string “0FF” as shown in Figure 14, press the On/Off switch to turn th

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 28 of 54 12. Set “auto-start” option. If the auto-start option is enabled, the generator

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 2 of 54 WARNING: Do not install or operate a Liberator™ (LI) system without completely rea

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 29 of 54 Operation For A.C. Modular Generator System (Reference XRT Manual for Operation In

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 30 of 54 3. The Command & Control Center is equipped with two Smart Touch® switches, la

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 31 of 54 6. If the system controller has been set to “auto-start”, the generator will begin

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 32 of 54 power output (electrical PLUS hydraulic) of the system in kilowatts (reference Figu

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 33 of 54 d. HI Curr. If the system measures a continuous current draw exceeding the genera

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 34 of 54 b. Note the y and n labels below the Mode and On/Off switches. Press the On/Off s

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 35 of 54 Message advising theoil is cold (less than40°F)Measured oiltemperature indegrees fa

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 36 of 54 e. That the hydraulic fluid level in the reservoir is between ½ to ¾ full in the s

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 37 of 54 Time Since last Oil Filter Change in Hours. Press Mode until FLt and Xr are display

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 38 of 54 will be removed and replaced by another screen. The fault has been cleared and the

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 3 of 54 Never operate the system with leaks of any type. Clean up any hydraulic fluid tha

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 39 of 54 Troubleshooting Guide For A.C. Modular Generator System (Reference XRT Manual for T

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 40 of 54 Diagnostic Faults: The following is a list of the diagnostic faults, with a brief

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 41 of 54 Note: The fault “Classes” are defined in the table below: Class Meaning Service Wa

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 42 of 54 After correcting any problems, again operate the generator twenty minutes to purge

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 43 of 54 4. System Overheating: System overheating may be caused by re-circulation of hot

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 44 of 54 Electrical Problems 1. No Output Voltage: a. No output voltage may be caused by

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 45 of 54 g. The pump is faulty. If no faults are found in steps a. through g., the proble

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 46 of 54 SPS Model Matrix PARENT P/N DESCRIPTIONCOMMAND & CONTROL CENTER P/N

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 47 of 54 PARENT P/N DESCRIPTIONCOMMAND & CONTROL C

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 48 of 54 PARENT P/N DESCRIPTIONCOMMAND & CONTROL CENTER P/NXRT KIT P/NTRAY AS

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 4 of 54 fill the pump case with a minimum of 1 pint of hydraulic fluid (Dexron III) before e

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 49 of 54 Pump Adjustment For A.C. Modular Generator System (Reference XRT Manual for Pump

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 50 of 54 The Pump Set option can be accessed by performing the following steps: Step b:

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 51 of 54 2. Adjust pump compensator: a. Reference Figure 30. b. Loosen the flow cont

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 52 of 54 3. Disable the generator Pump Set option. After the pump has been properly adju

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 53 of 54 Manufacturers Limited Warranty Smart Power® Systems Hydraulic Generator (NOTE: Th

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 54 of 54 3. Living and travel expenses of the person making the repair (other than those o

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 5 of 54 Disclaimer Although SPS has taken all reasonable care to ensure that the informati

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 6 of 54 Description of Product Hydraulic Generator / Rescue Tool Pump Applications: This h

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 7 of 54 CASE DRAINxyRESERVOIRPUMPPROPORTIONALVALVECASE DRAINMOTORCOOLERFILTERBOOST BLOCKVE

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 8 of 54 PROP. CONTROL VALVEP/N 8594452ASM, OIL TEMP. SENSORP/N 3310736INDICATOR BULBREMOTE E